Biomass Group, Nanjing Agricultural University, PO Box 68, 40 Dianjiangtai Road, Nanjing 210031

High Yield Production of Levoglucosan via Catalytic Pyrolysis of Cellulose at Low Temperature

Recently, Dr Li-Qun Jiang (Associate Prof., Institute of Biological and Medical Engineering, Guangdong Academy of Sciences), Prof. H Li (Guizhou University) and Prof. Zhen Fang published an article in Fuel about levoglucosan production from catalytic pyrolysis of cellulose with acid-base bifunctional magnetic Zn-Fe-C catalysts.

Catalytic pyrolysis of cellulose to levoglucosan in improved yields was achieved with acid-base bifunctional magnetic Zn-Fe-C catalysts. Among tested catalysts, Zn₄@Fe-C₅₀₀ could not only increase levoglucosan yield by 5.4 times compared with non-catalytic cellulose pyrolysis at 300 °C, but also help lower reaction temperature by 200 °C due to acid-base site synergistic effect. Furthermore, the levoglucosan yield (80.1 wt%) from catalytic cellulose pyrolysis at 300 °C was much higher than that commonly conducted at 500 °C without catalyst (60.1 wt%). Thermogravimetric and kinetic analysis disclosed levoglucosan formation mechanism. Importantly, Zn₄@Fe-C₅₀₀ catalyst was highly recyclable with little deactivation after 5 consecutive cycles. This study exhibited great potential for industrial levoglucosan production from cellulose at low temperatures. Related results were published in Fuel:

LQ Jiang, JC Luo, F Xu, L Qian, YT Wang, H Li*, Zhen Fang*, High Yield Production of Levoglucosan via Catalytic Pyrolysis of Cellulose at Low Temperature, Fuel, 323 (2022) 124369. https://doi.org/10.1016/j.fuel.2022.124369

.

Production of Levoglucosan via Catalytic Pyrolysis of Cellulose at Low Temperature with Zn_n@Fe-C_T acid-base bifunctional magnetic catalyst磁性固体酸碱两性催化剂Zn_n@Fe-C_T催化纤维素定向热解制备左旋葡聚糖

 磁性固体酸碱两性催化剂Zn_n@Fe-C_T催化纤维素定向热解制备左旋葡聚糖

最近，蒋丽群博士（广东省科学院生物与医学工程研究所副教授）, 李虎教授 （贵州大学）和方真教授在国际学术期刊Fuel（IF: 6.609，Q1）发表题为“High Yield Production of Levoglucosan via Catalytic Pyrolysis of Cellulose at Low Temperature”的研究性论文。该研究制备了磁性固体酸碱两性催化剂Zn_n@Fe-C_T用于催化纤维素快速热解选择性制取左旋葡聚糖。相关研究表明，Zn₄@Fe-C₅₀₀催化热解纤维素不仅可以将热解糖化反应温度从500 ℃降低至300 ℃，并且300 ℃下催化热解纤维素得到左旋葡聚糖的产率（80.1 wt%）远高于500℃（60.1 wt%）。经过5次循环实验后Zn₄@Fe-C₅₀₀仍然可以提升左旋葡聚糖的产率。该研究为纤维素定向热解转化提供了新思路。详情可见：

LQ Jiang, JC Luo, F Xu, L Qian, YT Wang, H Li*, Zhen Fang*, High Yield Production of Levoglucosan via Catalytic Pyrolysis of Cellulose at Low Temperature, Fuel, 323 (2022) 124369. https://doi.org/10.1016/j.fuel.2022.124369

.

NaFeO₂-Fe₃O₄合成生物柴油Highly stable NaFeO₂-Fe₃O₄ composite catalyst from blast furnace dust for efficient production of biodiesel at low temperature

Recently, Dr Yi-Tong Wang (Associate Prof., College of Metallurgy and Energy, North China University of Science and Technology) and Prof. Zhen Fang published an article in Industrial Crops & Products about using highly stable NaFeO₂-Fe₃O₄ composite catalyst from blast furnace dust for biodiesel production.

Highly stable catalysts were prepared by wet impregnation of blast furnace dust (BFD) in Na₂CO₃·H₂O, Na₂CO₃·10H₂O, NaHCO₃ and Na₂CrO₄ solution and subsequent calcination of 300-600 ^oC. At low temperature of 65 ^oC for 2 h with methanol/oil molar ratio of 15/1, high biodiesel yields of 100 wt% were obtained with 7wt% Na₂CO₃·H₂O@BFD₃₀₀ and Na₂CO₃·H₂O@BFD₄₀₀ catalyst (impregnating with Na₂CO₃·H₂O solution and calcining at 300 and 400 ^oC) added for the first use. Na₂CO₃·H₂O@BFD₃₀₀ catalyst exhibited outstanding stability and recyclability with biodiesel yields of 100 wt% at the fifth use (93 wt% at the twelfth use) owing to impregnated Na₂CO₃ reacting with Fe₂O₃ in dust to produce stable and active nanocomponents of NaFeO₂ (32.42 nm) and magnetic nanocomponent of Fe₃O₄ (size of 3.14 nm and Ms of 6.16 Am²/kg) in dust existing. The study provided practical guidance for biodiesel industrial production.

Related results were published in Industrial Crops & Products:

XM Wang, YN Zeng, LQ Jiang, YT Wang*, JG Li*, LL Kang, R Ji, D Gao, FP Wang, Q Yu, YJ Wang, Zhen Fang*. Highly stable NaFeO₂-Fe₃O₄ Composite Catalyst from Blast Furnace Dust for Efficient Production of Biodiesel at Low Temperature, Industrial Crops and Products, 182, 114937, https://doi.org/10.1016/j.indcrop.2022.114937 (2022).

Efficient production of biodiesel can be achieved with Na₂CO₃·H₂O@BFD₃₀₀ catalyst for 12 reuses with 92.56 wt% yield.使用Na₂CO₃·H₂O@BFD₃₀₀催化剂实现生物柴油高效生产，循环12次后，产率仍可达92.56 wt%。

王一同博士和方真教授在国际学术期刊Industrial Crops & Products发表学术论文:

高炉粉尘制备NaFeO₂-Fe₃O₄复合催化剂用于生物柴油合成

最近，王一同博士（华北理工大学冶金与能源学院副教授）和方真教授在国际学术期刊Industrial Crops & Products（IF: 5.645，Q1）发表题为“高炉粉尘制备NaFeO₂-Fe₃O₄复合催化剂用于生物柴油合成”的研究性论文。

利用Na₂CO₃·H₂O，Na₂CO₃·10H₂O，NaHCO₃和Na₂CrO₄水溶液分别湿法浸渍高炉粉尘，于300-600 ^oC高温活化制备高稳定性催化剂。在65 ^oC、醇油摩尔比15/1、催化剂用量7 wt%的条件下反应2 h，Na₂CO₃·H₂O@BFD₃₀₀和Na₂CO₃·H₂O@BFD₄₀₀催化剂获得了100 wt%的产率。由于浸渍的Na₂CO₃和高炉粉尘中的Fe₂O₃反应生成稳定且有活性的纳米组分NaFeO₂（32.42 nm）以及高炉粉尘中含有的磁性纳米组分Fe₃O₄（晶粒：3.14 nm；磁性：6.16 Am²/kg），Na₂CO₃·H₂O@BFD₃₀₀催化剂表现出优异的稳定性和可回收性，循环12次后仍可获得93 wt%的产率。该研究为生物柴油的工业化生产提供了实用指导。详情可见：

XM Wang, YN Zeng, LQ Jiang, YT Wang*, JG Li*, LL Kang, R Ji, D Gao, FP Wang, Q Yu, YJ Wang, Zhen Fang*. Highly stable NaFeO₂-Fe₃O₄ Composite Catalyst from Blast Furnace Dust for Efficient Production of Biodiesel at Low Temperature, Industrial Crops and Products (IF 5.6), 182, 114937, https://doi.org/10.1016/j.indcrop.2022.114937 (2022).

Production of biodiesel at low temperature using bifunctional Na-Fe-Ca nanocatalyst from blast furnace waste

Recently, Dr Yi-Tong Wang (Associate Prof., College of Metallurgy and Energy, North China University of Science and Technology) and Prof. Zhen Fang published an article in Fuel about using highly active bifunctional Na-Fe-Ca nanocatalyst from blast furnace dust for biodiesel production.

Nanocatalysts for biodiesel production were prepared via wet impregnation of blast furnace dust (BFD) in Na₂CO₃ (Na-BFD) and CaCO₃ (Ca-BFD) suspension solutions and calcination at 500 and 600 ^oC, respectively. Biodiesel yields of 100.0 wt% (Na-BFD₅₀₀) and 98.3 wt% (Ca-BFD₆₀₀) were achieved at 65 ^oC. Synthesized catalysts showed outstanding activity and recyclability, due to the transition of CaCO₃, Na₂CO₃ and Fe₂O₃ to nanocrystals of NaFeO₂ (29.9 nm), Ca₂Fe₂O₅ (10.5 nm), CaO (100.1 nm) and Ca₂Fe₂O₅ (50.0 nm). Na-BFD₅₀₀ achieved 95.8 wt% biodiesel yield with 16 cycles, whereas Ca-BFD₆₀₀ reached 94.1 wt% biodiesel yield with 7 cycles via magnetic separation. BFD containing convertible magnetic and active components (Fe₂O₃ and CaCO₃) was an ideal raw material to synthesize catalyst for biodiesel production with high catalytic efficiency and easy separation. The study provided a practical utilization of industrial solid waste for biodiesel production.

Related results were published in Fuel:

YT Wang, XM Wang, D Gao, FP Wang, YN Zeng, JG Li*, LQ Jiang, Q Yu, R Ji, LL Kang, YJ Wang, Zhen Fang*, Efficient Production of Biodiesel at Low Temperature Using Highly Active Bifunctional Na-Fe-Ca Nanocatalyst from Blast Furnace Waste, Fuel, 322, 124168, https://doi.org/10.1016/j.fuel.2022.124168 (2022).

Nanocatalysts produced by impregnation and calcination transesterified soybean oil to biodiesel with 100 wt% yield. 通过浸渍和煅烧制备了纳米催化剂用于催化豆油酯交换制备生物柴油，产率高达100 wt%。

高炉粉尘制备双功能Na-Fe-Ca纳米催化剂用于生物柴油合成

最近，王一同博士（华北理工大学冶金与能源学院副教授）和方真教授在国际学术期刊Fuel（IF: 6.609，Q1）发表题为“高炉粉尘制备双功能Na-Fe-Ca纳米催化剂用于生物柴油合成”的研究性论文。

利用Na₂CO₃和CaCO₃水溶液分别湿法浸渍高炉粉尘，于500 ℃和600 ^oC高温活化制备纳米催化剂（Na-BFD₅₀₀和Ca-BFD₆₀₀），用于催化豆油制备生物柴油。催化剂经高温煅烧后，CaCO₃、Na₂CO₃和Fe₂O₃晶体转变为纳米NaFeO₂（29.9 nm）、Ca₂Fe₂O₅（10.5 nm）、CaO（100.1 nm）和Ca₂Fe₂O₅（50 nm）晶体，表现出优异的催化活性和可循环利用特性。Na-BFD₅₀₀催化豆油制备生物柴油的产率达到100.0 wt%，循环16次后仍可获得95.8 wt%的产率，而Ca-BFD₆₀₀催化豆油制备生物柴油的产率达到98.3 wt%，循环7次后仍可获得94.1 wt%的产率。该研究为工业固体废物用于生物柴油制备提供了新思路。详情可见：

YT Wang, XM Wang, D Gao, FP Wang, YN Zeng, JG Li*, LQ Jiang, Q Yu, R Ji, LL Kang, YJ Wang, Zhen Fang*, Efficient Production of Biodiesel at Low Temperature Using Highly Active Bifunctional Na-Fe-Ca Nanocatalyst from Blast Furnace Waste, Fuel (IF 6.6), 322, 124168, https://doi.org/10.1016/j.fuel.2022.124168 (2022).

捐书: 20 books were donated by Prof. Zhen Fang

On Feb. 8, 2022, Prof. Zhen Fang donated 20 books edited/authored by him in renewable energy and green technologies to his hometown in Fujian:

1. 1.P Bartocci, F Fantozzi, Q Yang, HP Yang, O Masek, YJ Yan, Zhen Fang, L Rigamonti, (Editors), Sustainable Biomass and Waste Conversion, Elsevier, 2022.
2. 2.Zhen Fang, RL Smith, Jr., LJ Xu (Editors), Production of Biofuels and Chemicals from Sustainable Recycling of Organic Solid Waste, Springer, Heidelberg Berlin, 2021.
3. 3.Zhen Fang, RL Smith, Jr., LJ Xu (Editors), Production of Biofuels and Chemicals with Pyrolysis, Springer, Heidelberg Berlin, 2020.
4. 4.YT Wang, Zhen Fang (Editors), Catalytic Biomass to Renewable Biofuels and Biomaterials, MDPI (Basel, Switzerland), 2020.
5. 5.Zhen Fang, RL Smith, Jr., XF Tian (Editors), Production of Materials from Sustainable Biomass Resources, Springer, Heidelberg Berlin, 2019.
6. 6.Zhen Fang, RL Smith, Jr., H Li (Editors), Production of Biofuels and Chemicals with Bifunctional Catalysts, Springer, Heidelberg Berlin, 2017.
7. 7.Zhen Fang, RL Smith, Jr., X Qi (Editors), Production of Platform Chemicals from Sustainable Resources, Springer, Heidelberg Berlin, 2017.
8. 8.Zhen Fang, RL Smith, Jr.(Editors), Production of Biofuels and Chemicals from Lignin, Springer, Heidelberg Berlin, 2016.
9. 9.Zhen Fang, RL Smith, Jr., X Qi (Editors), Production of Hydrogen from Renewable Resources, Springer, Heidelberg Berlin, 2015.
10. 10.Zhen Fang, RL Smith, Jr., X Qi (Editors), Production of Biofuels and Chemicals with Microwave, Springer, Heidelberg Berlin, 2015.
11. 11.Zhen Fang, RL Smith, Jr., X Qi (Editors), Production of Biofuels and Chemicals with Ultrasound, Springer, Heidelberg Berlin, 2015.
12. 12.Zhen Fang, C Xu (Editors), Near-critical and Supercritical Water and Their Applications for Biorefineries, Springer, Heidelberg Berlin, 2014.
13. 13.Zhen Fang, RL Smith, Jr., X Qi (Editors), Production of Biofuels and Chemicals with Ionic Liquids, Springer, Heidelberg Berlin, 2014.
14. 14.Zhen Fang (Editor), Liquid, Gaseous and Solid Biofuels – Conversion Techniques, InTech, London, UK, 2013.
15. 15.Zhen Fang (Editor), Biofuels – Economy, Environment and Sustainability, InTech, London, UK, 2013.
16. 16.Zhen Fang (Editor), Pretreatment Techniques for Biofuels and Biorefineries, Springer, Berlin Heidelberg, 2013.
17. 17.Zhen Fang (Editor), Biodiesel – Feedstocks, Production and Applications, InTech, London, UK, 2013.
18. 18.J. M. Marchetti, Zhen Fang (Editors), Biodiesel: Blends, Properties and Applications, Nova Science Publishers, Inc., New York, 2011.
19. 19.Zhen Fang (Author), Rapid Production of Micro- and Nano-particles Using Supercritical Water, Springer, Berlin Heidelberg, 2010.
20. 20.Zhen Fang (Author), Complete Dissolution and Oxidation of Organic Wastes in Water, VDM Verlag Dr. Müller, Saarbrücken, Germany, 2009.

hdrpl

2月8日，方真教授档案图书捐赠仪式在泰宁县档案馆举行。

县领导黄维云出席仪式并讲话。

会上，县领导对方真先生的到来表示热忱的欢迎，对方院士热心捐赠珍贵的图书档案资料表示最诚挚的感谢！此次，方真院士捐赠的院士证书及他编著的20册珍贵图书档案资料（其中2部随后寄送），将进一步丰富泰宁县档案馆馆藏，助力科技事业的发展。

翻译：

1.P Bartocci，F Fantozzi，Q Yang，HP Yang，O Masek，YJ Yan，方真，L Rigamonti，（编著），《可持续生物质和废弃物转化》，爱思唯尔出版社，2022

2.方真，RL Smith，Jr.，徐禄江（编著），《可持续再生有机固体废物生产生物燃料和化学品》，柏林•海德堡，斯普林格出版社，2021

3.方真，RL Smith，Jr.，徐禄江（编著），《热解生产生物燃料和化学品》，柏林•海德堡，斯普林格出版社，2020

4.王一同，方真 （编著），《催化生物质转化为可再生生物燃料和生物材料》，MDPI（瑞士巴塞尔）出版社，2020

5.方真，RL Smith，Jr.，田霄飞（编著），《可持续生物质资源生产材料》，柏林•海德堡，斯普林格出版社，2019

6.方真，RL Smith，Jr.，李虎（编著），《双功能催化剂生产生物燃料和化学品》，柏林•海德堡，斯普林格出版社，2017

7.方真，RL Smith，Jr.，漆新华（编著），《可持续资源生产平台化学品》，柏林•海德堡，斯普林格出版社，2017

8.方真，RL Smith，Jr.（编著），《木质素生产生物燃料和化学品》，柏林•海德堡，斯普林格出版社，2016

9.方真，RL Smith，Jr.，漆新华（编著），《可再生资源生产氢气》，柏林•海德堡，斯普林格出版社，2015

10.方真，RL Smith，Jr.，漆新华（编著），《利用微波生产生物燃料和化学品》，柏林•海德堡，斯普林格出版社，2015

11.方真，RL Smith，Jr.，漆新华（编著），《利用超声波生产生物燃料和化学品》，柏林•海德堡，斯普林格出版社，2015

12.方真，徐春保（编著），《近临界水和超临界水及其在生物炼制中的应用》，柏林•海德堡，斯普林格出版社，2014

13.方真，RL Smith，Jr.，漆新华（编著），《利用离子液体生产生物燃料和化学品》，柏林•海德堡，斯普林格出版社，2014

14.方真（编著），《液体、气体和固体生物燃料-转化技术》，InTech出版社，英国，伦敦，2013

15.方真（编著），《生物燃料-经济、环境和可持续性》，InTech出版社，英国，伦敦，2013

16.方真（编著），《生物燃料和生物精炼的预处理技术》，柏林•海德堡，斯普林格出版社，2013

17.方真（编著），《生物柴油-原料、生产和应用》，InTech出版社，英国，伦敦，2013

18.JM Marchetti，方真（编著），《生物柴油：混合物、性质和应用》，Nova Science Publishers出版社，纽约，2011

19.方真（作者），《超临界水快速制备微米和纳米颗粒》，柏林•海德堡，斯普林格出版社，2010

20.方真（作者），《水中有机废物的完全溶解和氧化》，德国，萨尔布吕肯，VDM Verlag Dr. Müller出版社，2009

碱颗粒球磨预处理: Efficient saccharification of wheat straw pretreated by solid particle-assisted ball milling with waste washing liquor recycling

Recently, PhD student Miss Xiao-le Liu supervised by Prof. Zhen Fang published a research article in Bioresource Technology about ball milling pretreatment with NaOH solid particles for enzymatic hydrolysis of wheat straw.

Wheat straw was pretreated using ball milling (BM) promoted by solid particles (NaOH, NaCl, citric acid). NaOH showed the best synergistic interaction effect, due to the breakage of β-1,4-glycosidic bonds among cellulose molecules by the alkali solid particles induced by BM. NaOH-BM pretreatment decreased the straw crystallinity from 46% to 21.4% and its average particle size from 398.3 to 50.6 μm in 1 h. After 4 h milling, the reducing-end concentration of cellulose increased by 3.8 times from 12.5 to 60.2 μM, with glucose yield increased by 2.1 times from 26.6% to 82.4% for 72 h enzymatic hydrolysis at cellulase loading of 15 FPU/g dry substrate. The pretreatment washing liquor was recycled for the re-treatment of partially pretreated biomass at 121 °C for 30 min, resulting in 99.4% glucose yield by enzymatic hydrolysis. BM assisted with alkali particles was an effective approach for improving biomass enzymatic saccharification.

Related results were published in Bioresource Technology:

XL Liu, CY Dong, SY Leu, Zhen Fang* (Supervisor), ZD Miao, Efficient Saccharification of Wheat Straw Pretreated by Solid Particle-Assisted Ball Milling with Waste Washing Liquor Recycling, Bioresource Technology, 347, 126721, https://doi.org/10.1016/j.biortech.2022.126721 (2022).

Wheat straw was ball milling pretreated with NaOH particles for 4 h with 82.4% glucose yield after 72 h enzymatic hydrolysis. The pretreatment washing liquor was recycled for the re-treatment of partially pretreated biomass at 121 °C for 30 min, resulting in 99.4% glucose yield. （球磨辅助NaOH颗粒预处理小麦秸秆4 h。酶水解72 h，预处理后小麦秸秆酶解率为82.4%。预处理后的水洗液循环利用，在121°C下，对预处理4 h后的小麦秸秆再预处理30 min，酶解率提高到99.4%）

球磨辅助固体颗粒预处理小麦秸秆的高效糖化及水洗废液的循环利用

最近，博士生刘小乐（女）在方真教授的指导下，在国际学术期刊Bioresource Technology （Q1, IF 9.6）发表一篇关于球磨辅助NaOH颗粒预处理小麦秸秆用于酶解的研究性论文。

通过球磨辅助固体颗粒(NaOH、NaCl，柠檬酸)预处理小麦秸秆。其中，球磨辅助NaOH颗粒预处理的协同作用最好，这可能是由于球磨可以使NaOH破坏纤维素分子间的β-1,4-糖苷键。球磨辅助NaOH颗粒预处理1 h后，纤维素结晶度从46%降为21.4%，平均粒径从398.3 μm降到50.6 μm。球磨辅助NaOH颗粒预处理4 h后，在15 FPU/g干底物的条件下酶解72 h，酶解率从26.6%提高到82.4%，酶解率较原始小麦秸秆提高2.1倍。对预处理后的水洗液进行循环利用，在121 ℃下对预处理4 h后的秸秆再预处理30 min，酶解率提高为99.4%。

结果发表在Bioresource Technology：

XL Liu, CY Dong, SY Leu, Zhen Fang* (Supervisor), ZD Miao, Efficient Saccharification of Wheat Straw Pretreated by Solid Particle-Assisted Ball Milling with Waste Washing Liquor Recycling, Bioresource Technology, 347, 126721, https://doi.org/10.1016/j.biortech.2022.126721 (2022).